[空调] 拨动开关损坏,不接收遥控信号

技术支持评论2,107字数 2143阅读7分8秒阅读模式

拨动开关损坏,不接收遥控信号

故障说明

海信KFRP-35GW挂式交流变频空调器不定时出现不接收遥控信号、自动开/关机等故障。

故障现象

海信KFRP-35GW、KFRP-40GW、KFR-32GW/BP等系列机型,为海信第一代交流变频空调器,生产线全套引进三洋技术,社会拥有量很大,由于故障率较低,目前部分空调器仍在使用,但此机使用几年之后,容易出现以下故障,如图1所示。

①不接收遥控信号。

②4个指示灯乱闪。

③自动开、关机(自动开机制冷)。

④室内风机自动运行,但一段时间后又自动停止运行。

 

图1 故障现象

图1 故障现象

 

引发的故障原因为此机型功能开关为拨动型(见图2),共有4个挡位:关、开、试运转、演示开关。拨动开关的主要作用是调出故障代码和改变空调器的状态。正常使用时其在“开”位置,当拨至“关”位置时,3个指示灯以“亮、灭、闪”的组合方式显示故障代码;拨至“演示开关”时可演示空调器的功能;当遥控器丢失或暂时不在身边,可拨至“试运转”位置开启空调器,使用完毕后拨至“关”位置即可关机。

 

图2拔动开关安装位置和4个挡位

图2拔动开关安装位置和4个挡位

 

拨动开关使用触点接触形式,在使用一段时间后,接触部位容易产生锈点,引起内阻增大,出现接触不良的故障。假如拨动开关在正常的“开”位置,而CPU检测在“关”位置,则引起不接收遥控信号故障,空调器不能开机;CPU检测在“演示开关”位置,表现为4个指示灯同时乱闪;当CPU检测在“试运转”位置,空调器则自动开机和关机。

说明:本机在空调器出现故障,室内机CPU诊断出故障代码之后,并不直接显示,而是记忆在室内机主板内存之中,即使空调器断开电源也不会消除。故障代码查看方法是将拨动开关由“开”位置拨至“关”位置即能查看,查看后需要将代码清除,方法为拔下空调器电源,将拨动开关拨至“演示开关”位置,再插上空调器电源,此时蜂鸣器长响一声,表示代码已清除,再将拨动开关拨至“关”位置,此时不再显示代码,再拨至“开”位置,空调器即能正常使用。

如图3所示,室内机主板通过1组引线连接拨动开关,拨动开关由外壳、拨动装置、电路板组成。

 

图3 拔动开连接方式及内部结构

图3 拔动开连接方式及内部结构

 

图4所示为拨动开关电路板的正面与背面,从图中可以看出,连接引线共有7根,其中4根驱动3个指示灯,另外3根检测拨动开关的挡位。

 

图4 拔动开关电路板

图4 拔动开关电路板

 

1号线为3个指示灯D10、D20、D30的公共端,2号线驱动D30,3号线驱动D20,4号线驱动D10。

5号、6号、7号线连接拨动开关,5号相当于公共端。挡位位置与引线状态对应关系见图5。

 

图5 挡位位置和引线状态对应关系

图5 挡位位置和引线状态对应关系

 维修措施

1.清除拨动开关锈点方法

①首先取下电路板上拨动开关表面的固定铁壳,由于固定铁壳的铁皮比较薄,拆下时应使用比较薄的刀片轻轻撬开,取下后可看到拨动开关由挡位、拨叉、固定铁壳组成,如图6所示。引起故障的原因就是挡位表面铜板和拨叉有锈点,产生内阻而引起的绝缘下降。

 

图6 故障原因

图6 故障原因

 

②如图7所示,使用针尖轻轻划过挡位表面铜板,以清除表面的锈点,要注意两道铜板的接触面都要清除;再使用针尖将拨叉接触面的锈点也清除干净,再将拨叉的接触面向上轻轻扳一些,以增加接触压力,避免出现接触不良的故障。

 

图7 维修方法

图7 维修方法

 

③清洗完毕后就要安装了,先将拨叉安装在挡位上面,注意方面不要装反,再将固定铁壳装好,拨动开关的清洗工作就已经完成,然后再安装外壳和拨动装置,安装连接引线后,将拨动开关安装试机,出现的上述几种故障即可排除。

2.更改连接引线排除故障方法

如果现场维修清除拨动开关锈点不方便或清除完成后故障依旧,但确定故障根源在拨动开关上面,可利用引线的功能来维修,即直接短接引线,使室内机主板CPU检测状态一直在“开”的位置。

①不再使用拨动开关。如图8所示,剪断拨动开关的7根连接引线,拨动开关不再使用,将其中的5号引线和7号连接引线剥开,并直接连接在一起,使用防水胶布缠好接头,将插头安装在室内机主板上面,这样室内机CPU检测拨动开关位置一直为“开”,由拨动开关引发的各种故障可彻底排除。

 

图8 短路5号和7号引线

图8 短路5号和7号引线

 

注意:连接前应先清除室内机主板内存的故障代码。

②只断开拨动开关功能,保留3个指示灯。如图9所示,剪断连接拨动开关的3根引线,即5号、6号、7号,并将5号和7号连接在一起,接头使用胶布做好绝缘,再将插头连接至室内机主板,这样室内机CPU检测拨动开关一直为“开”位置,此种方法可保留拨动开关上面的3个指示灯。

 

图9 短路5号和7号引线

图9 短路5号和7号引线



定陶友信家电维修、制冷维修
专业家电维修、制冷维修、管道疏通等

服务方式: 1:上门服务 2:送货上店 3:上门取货。

售后服务: 家电、制冷维修类均有售后服务。

联系电话: 15315643616

空调维修(定频、变频、挂机、柜机、吸顶机、嵌入机、风管机、中央空调等):
服务项目:空调安装、移机、加氟、维修(不开机、不制热、不制冷、制冷制热缓慢等全部故障)、保养(清洗)、回收/出售二手空调等;
服务品牌:格力、美的、海尔、春兰、奥克斯、松下、日立、伊莱克斯、三洋、志高、海信、三菱、科龙、大金、格兰仕、长虹、LG、三星、TCL、澳柯玛、惠而浦、夏普、开利、双鹿、特灵、扬子、华凌、清华同方、富士通、小鸭、长府、惠而浦、绅宝、胜风 、飞鹿、凉宇、东洋等国内外各种品牌;



Warning: file_exists(): open_basedir restriction in effect. File(/www/wwwroot/www.yxjdzl.com/wp-content/uploads/2024/03) is not within the allowed path(s): (/www/wwwroot/yxjdzl.com/:/tmp/) in /www/wwwroot/yxjdzl.com/wp-includes/functions.php on line 2036

Warning: is_dir(): open_basedir restriction in effect. File(/www/wwwroot/www.yxjdzl.com/wp-content/uploads/2024) is not within the allowed path(s): (/www/wwwroot/yxjdzl.com/:/tmp/) in /www/wwwroot/yxjdzl.com/wp-includes/functions.php on line 2047

Warning: is_dir(): open_basedir restriction in effect. File(/www/wwwroot/www.yxjdzl.com/wp-content/uploads) is not within the allowed path(s): (/www/wwwroot/yxjdzl.com/:/tmp/) in /www/wwwroot/yxjdzl.com/wp-includes/functions.php on line 2047

Warning: is_dir(): open_basedir restriction in effect. File(/www/wwwroot/www.yxjdzl.com/wp-content) is not within the allowed path(s): (/www/wwwroot/yxjdzl.com/:/tmp/) in /www/wwwroot/yxjdzl.com/wp-includes/functions.php on line 2047

Warning: is_dir(): open_basedir restriction in effect. File(/www/wwwroot/www.yxjdzl.com) is not within the allowed path(s): (/www/wwwroot/yxjdzl.com/:/tmp/) in /www/wwwroot/yxjdzl.com/wp-includes/functions.php on line 2047

Warning: is_dir(): open_basedir restriction in effect. File(/www/wwwroot) is not within the allowed path(s): (/www/wwwroot/yxjdzl.com/:/tmp/) in /www/wwwroot/yxjdzl.com/wp-includes/functions.php on line 2047

Warning: is_dir(): open_basedir restriction in effect. File(/www) is not within the allowed path(s): (/www/wwwroot/yxjdzl.com/:/tmp/) in /www/wwwroot/yxjdzl.com/wp-includes/functions.php on line 2047

Warning: is_dir(): open_basedir restriction in effect. File(/) is not within the allowed path(s): (/www/wwwroot/yxjdzl.com/:/tmp/) in /www/wwwroot/yxjdzl.com/wp-includes/functions.php on line 2047

Warning: is_dir(): open_basedir restriction in effect. File(/www/wwwroot/www.yxjdzl.com/wp-content/uploads/avatar) is not within the allowed path(s): (/www/wwwroot/yxjdzl.com/:/tmp/) in /www/wwwroot/yxjdzl.com/wp-content/themes/begin/inc/avatar-cache.php on line 7

Warning: file_exists(): open_basedir restriction in effect. File(/www/wwwroot/www.yxjdzl.com/wp-content/uploads/avatar) is not within the allowed path(s): (/www/wwwroot/yxjdzl.com/:/tmp/) in /www/wwwroot/yxjdzl.com/wp-includes/functions.php on line 2036

Warning: is_dir(): open_basedir restriction in effect. File(/www/wwwroot/www.yxjdzl.com/wp-content/uploads) is not within the allowed path(s): (/www/wwwroot/yxjdzl.com/:/tmp/) in /www/wwwroot/yxjdzl.com/wp-includes/functions.php on line 2047

Warning: is_dir(): open_basedir restriction in effect. File(/www/wwwroot/www.yxjdzl.com/wp-content) is not within the allowed path(s): (/www/wwwroot/yxjdzl.com/:/tmp/) in /www/wwwroot/yxjdzl.com/wp-includes/functions.php on line 2047

Warning: is_dir(): open_basedir restriction in effect. File(/www/wwwroot/www.yxjdzl.com) is not within the allowed path(s): (/www/wwwroot/yxjdzl.com/:/tmp/) in /www/wwwroot/yxjdzl.com/wp-includes/functions.php on line 2047

Warning: is_dir(): open_basedir restriction in effect. File(/www/wwwroot) is not within the allowed path(s): (/www/wwwroot/yxjdzl.com/:/tmp/) in /www/wwwroot/yxjdzl.com/wp-includes/functions.php on line 2047

Warning: is_dir(): open_basedir restriction in effect. File(/www) is not within the allowed path(s): (/www/wwwroot/yxjdzl.com/:/tmp/) in /www/wwwroot/yxjdzl.com/wp-includes/functions.php on line 2047

Warning: is_dir(): open_basedir restriction in effect. File(/) is not within the allowed path(s): (/www/wwwroot/yxjdzl.com/:/tmp/) in /www/wwwroot/yxjdzl.com/wp-includes/functions.php on line 2047

Warning: is_file(): open_basedir restriction in effect. File(/www/wwwroot/www.yxjdzl.com/wp-content/uploads/avatar/b32f9e95aaf5f958e5327dc1538e4e1c96.png) is not within the allowed path(s): (/www/wwwroot/yxjdzl.com/:/tmp/) in /www/wwwroot/yxjdzl.com/wp-content/themes/begin/inc/avatar-cache.php on line 21

Warning: is_file(): open_basedir restriction in effect. File(/www/wwwroot/www.yxjdzl.com/wp-content/uploads/avatar/b32f9e95aaf5f958e5327dc1538e4e1c-d.png) is not within the allowed path(s): (/www/wwwroot/yxjdzl.com/:/tmp/) in /www/wwwroot/yxjdzl.com/wp-content/themes/begin/inc/avatar-cache.php on line 22

Warning: fopen(): open_basedir restriction in effect. File(/www/wwwroot/www.yxjdzl.com/wp-content/uploads/avatar/b32f9e95aaf5f958e5327dc1538e4e1c-d.png) is not within the allowed path(s): (/www/wwwroot/yxjdzl.com/:/tmp/) in /www/wwwroot/yxjdzl.com/wp-content/themes/begin/inc/avatar-cache.php on line 26

Warning: fopen(/www/wwwroot/www.yxjdzl.com/wp-content/uploads/avatar/b32f9e95aaf5f958e5327dc1538e4e1c-d.png): Failed to open stream: Operation not permitted in /www/wwwroot/yxjdzl.com/wp-content/themes/begin/inc/avatar-cache.php on line 26

Fatal error: Uncaught TypeError: fclose(): Argument #1 ($stream) must be of type resource, bool given in /www/wwwroot/yxjdzl.com/wp-content/themes/begin/inc/avatar-cache.php:27 Stack trace: #0 /www/wwwroot/yxjdzl.com/wp-content/themes/begin/inc/avatar-cache.php(27): fclose() #1 /www/wwwroot/yxjdzl.com/wp-content/themes/begin/template/copyright.php(21): begin_avatar() #2 /www/wwwroot/yxjdzl.com/wp-includes/template.php(772): require('...') #3 /www/wwwroot/yxjdzl.com/wp-includes/template.php(716): load_template() #4 /www/wwwroot/yxjdzl.com/wp-includes/general-template.php(204): locate_template() #5 /www/wwwroot/yxjdzl.com/wp-content/themes/begin/single-default.php(16): get_template_part() #6 /www/wwwroot/yxjdzl.com/wp-includes/template.php(772): require('...') #7 /www/wwwroot/yxjdzl.com/wp-includes/template.php(716): load_template() #8 /www/wwwroot/yxjdzl.com/wp-includes/general-template.php(204): locate_template() #9 /www/wwwroot/yxjdzl.com/wp-content/themes/begin/single.php(6): get_template_part() #10 /www/wwwroot/yxjdzl.com/wp-includes/template-loader.php(106): include('...') #11 /www/wwwroot/yxjdzl.com/wp-blog-header.php(19): require_once('...') #12 /www/wwwroot/yxjdzl.com/index.php(17): require('...') #13 {main} thrown in /www/wwwroot/yxjdzl.com/wp-content/themes/begin/inc/avatar-cache.php on line 27
WordPress › 错误